Frymaster Electric Cooker 8C Manual de usuario

Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. 24-Hour Service Hotline 1-

2-3 2.4 Connecting to the Electrical Power Supply DANGER This unit must be connected to the voltage and phase specified on the rating and serial nu

2-4 FIELD CONNECTION WIRING DIAGRAMS SINGLE PHASE (NO NEUTRAL)FIELD CONNECTIONL1L2 L311HV1C12HV1C2233HV1C3456FROM TRANSFORMERFROMTRANSFORMER3 PHASE

3-1 ELECTRIC COOKERS 8SMS, 8BC AND 8C CHAPTER 3: OPERATING INSTRUCTIONS 165432 78 9 1 Numeric Keypad 6 Skim Switch (w/Autoskim only) 2 Boil M

3-2 ciency of the cooker and can cause erroneous temperature and water level sensing. NOTE: Do not use deliming solution to clean these units. Use of

3-3 3.3 Toggling Between Fahrenheit and Celsius Temperature Display There are two versions of the SMS Controller: one that can be toggled between F

4-1 ELECTRIC COOKERS 8SMS, 8BC AND 8C CHAPTER 4: PREVENTIVE MAINTENANCE 4.1 Daily Preventive Maintenance It is normal for a coating of starch to f

4-2 4.2 SMS II Controller Simmer Mode Adjustment NOTE: The SMS II Controller simmer temperature is adjustable from 185ºF to 215ºF. 1. With the u

5-1 ELECTRIC COOKERS 8SMS, 8BC AND 8C CHAPTER 5: OPERATOR TROUBLESHOOTING 5.1 Introduction This chapter provides an easy reference guide to the more

5-2 ON UNIT WITH AUTOFILL,COOKPOT DID NOT FILLWHEN UNIT WASTURNED ON. WATERSUPPLY TO UNITVERIFIED TO BE ON.Did anythingappear in controllerdisplay wh

5-3 Operator Troubleshooting Guides (Continued) ON UNIT WITHAUTOFILL, WATER DIDNOT SHUT OFF WHENCOOKPOT WAS FULL.Clean the waterlevel sensors.Did the

THIS EQUIPMENT IS INTENDED FOR INDOOR USE ONLY. DO NOT INSTALL OR OPERATE THIS EQUIPMENT IN OUTDOOR AREAS. DO NOT OPERATE THIS EQUIPMENT WITHOUT FIR

5-4 Operator Troubleshooting Guides (Continued) WATER WILL NOTBOIL. COOKPOTVERIFIED TO BE FULLOF WATER WITH BOILMODE SELECTED (i.e.,left indicator i

5-5 Operator Troubleshooting Guides (Continued) WATER BOILSIN SIMMERMODE.Adjust controller inaccordance withprocedure in Chapter 4.Did boilingstop?Pr

5-6 Operator Troubleshooting Guides (Continued) WATERTEMPERATUREIS TOO LOW INSIMMER MODE.Adjust controller inaccordance withprocedure in Chapter 4.Di

5-7 Operator Troubleshooting Guides (Continued) BASKET LIFT DOESNOT FUNCTIONCORRECTLY.Check the right-side5-amp fuse. Replace ifblown, then attempt

5-8 5.3 Replacing the Controller or Controller Wiring Harness 1. Disconnect the cooker from the electrical supply. 2. Remove the two screws in th

6-1 ELECTRIC COOKERS 8SMS, 8BC AND 8C CHAPTER 6: SERVICE PROCEDURES 6.1 Functional Description of Electric Cookers 8SMS, 8BC and 8C Electric Cook

6-2 6.2 Accessing Equipment for Servicing DANGER Moving this equipment while it is filled with hot water may cause spilling or splattering of the h

6-3 NOTE: This is a composite drawing for illustrative purposes only. It shows all partsthat may be mounted in the component box. Depending upon th

6-4 7. Position the replacement element in the cookpot with the standoffs on the bottom of the cookpot, and thread the element leads through the Tefl

6-5 4. Loosen the small compression nut, then unscrew the large fitting from the cookpot. 5. Remove the two screws securing the thermostat to the m

i ELECTRIC COOKERS 8SMS, 8BC AND 8C TABLE OF CONTENTS CHAPTER 1: General Information 1.1 Parts Ordering and Service Information ...

6-6 4. If replacing a water level sensor: a. Disconnect the lead by removing the keps nut holding it in place. b. Remove the screw in the sensor f

6-7 6.3.7 Replacing the Water Faucet 1. Drain the cookpot and disconnect the cooker from the electrical power supply. 2. Turn off the water suppl

6-8 8. Assemble the replacement faucet to the mounting bracket and complete the procedure by reversing Steps 1-6. 6.3.8 Replacing the Cookpot or Ri

6-9 5. If the unit is equipped with a pressure regulator, disconnect the regulator from the water line at the outlet side. Disconnect at thiscompre

6-10 6.3.9 Replacing the Basket Lift Motor and Related Components 1. Disconnect the unit from the electrical power supply and dismount the basket l

6-11 6.4 Troubleshooting 6.4.1 How the Autofill System Works The heart of the automatic filling (AutoFill) system is a normally closed solenoid val

6-12 The contactor block is the terminal block to which the element leads are connected and where actual contact is made between the leads and the li

6-13 Technician Troubleshooting Guides (Continued) TROUBLESHOOTINGTHE BASKET LIFTWith the basket liftin the UP position, is 13-17VDCpresent at pin 1

6-14 Technician Troubleshooting Guides (Continued) On 8SMS and 8BC units, is 13-17VDCpresent at pin 10 when lift is in UP positionand zero VDC when l

6-15 Technician Troubleshooting Guides (Continued) Before performing the following checks, disconnect the unit from theelectrical power source and ch

ii 6.4 Troubleshooting... 6-11 6.4.1 How th

6-16 6.5 Wiring Diagrams NCALL READINGS REFERENCED TO GROUND WITH THE COMPUTER OPERATINGCOMPUTER CONTROLFIELD CONNECTIONSINGLE PHASE24VAC1NCCOM23451C

6-17 GMCN.C. N.O.MICROSWITCHGEARMOTORCONNECTORLINELOADCONTACTOR COILSOLENOID1 2 3 4 5 6 7 8 91011121314151 2 3 4 5 6 7 8 910111213141513 5 7 9112

7-1 ELECTRIC COOKERS 8SMS, 8BC AND 8C CHAPTER 7: PARTS LIST 7.1 Accessories 12347568910111213 ITEM PART # COMPONENT 1 810-2112 Basket Hanger,

7-2 7.2 Basket Lift Components 1 2 3 4 5 6 7 8 9 10 1112131415161718192021222324252627

7-3 ITEM PART # COMPONENT 1 809-0127 Screw, ¼-20 x ½-inch Round Head 2 810-0192 Rod, Basket Lift 3 823-1840 Arm, Basket Lift 4 900-7226 Enclosu

7-4 7.3 Cabinetry 1356112a98101213141541616a16b16c16d16e1718192021 232224262517111272b

7-5 ITEM PART # COMPONENT 1 806-9744SP Door Assembly (does not include handles) 2a 810-1402 Handle, Wireform Door (cannot replace 210-9214) 2b 2

7-6 7.4 Cookpot and Rinse Tank Components 1 2 3 4 5 6 7 8 9 1011121327262524232221201918141516172829 8 8 9 101112303125 33 329102423222120151419347

7-7 ITEM PART # COMPONENT 1 810-0698 Cookpot, 8SMS/8BC/8C 2 810-1697 Block, Probe * 826-1081 Kit, Probe Block (old style with pins and cover) * 8

7-8 7.5 Electrical Components and Controllers 12342368910111213 14 151216 171820211957 ITEM PART # COMPONENT 1 807-1396 Relay, 24VDC 2 807-1308 Hol

1-1 ELECTRIC COOKERS 8SMS, 8BC AND 8C CHAPTER 1: GENERAL INFORMATION 1.1 Parts Ordering and Service Information In order to assist you as quickly a

7-9 7.6 Water Supply Components 123456798111213106 ITEM PART # COMPONENT 1 806-4770 Solenoid Assembly, Autofill 2 810-1208 Regulator, Water Pres

THIS PAGE INTENTIONALLY LEFT BLANK

Frymaster, L.L.C., 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000 Shipping Address: 8700 Line Avenue, Shreveport, Louisiana 71106

1-2 WARNING WARNING boxes contain information about actions or conditions that may cause or result in damage to your equipment, and which may cause y

1-3 1.5 Definitions QUALIFIED AND/OR AUTHORIZED OPERATING PERSONNEL Qualified/authorized operating personnel are those who have carefully read the in

2-1 ELECTRIC COOKERS 8SMS, 8BC AND 8C CHAPTER 2: INSTALLATION INSTRUCTIONS 2.1 General Installation Requirements PROPER INSTALLATION IS ESSENTIAL F

2-2 2.2 Caster/Leg Installation Depending upon the specific configuration ordered, your unit might have been shipped without in-stalled casters or leg